And so it Begins- The Shed Part 1

I tore my old shed down one fall day and told myself that I would build a new one in the spring. That was seven years ago. Well, after seven years, I finally got my act together to build a new shed. One of the biggest issues in building it was how to build it level with a yard that is sloped downhill. I considered using deck blocks, but after watching a few YouTube videos, I decided to build a framed base.

 photo 20150830_143127.jpg

My wife, Anita, and I decided how big of a shed we wanted and where to put it in the yard. We opted for a 10′ x 14′ and laid it out in the yard with stakes and strings. I then used a line level to see how far off the ground the right side of the shed would be in the air. It’ll end up being about two feet in the air on the back right side which won’t look bad once we plant some shrubs around the shed.

 photo 20151011_161104.jpg

After we went to the home center to pick up the lumber. I cut and screwed the 2×6’s together into a 10′ x 14′ box. I measured corner to corner to make sure the box was square then attached boards on all four corners to keep it that way. I then grabbed some spray paint and sprayed the ground at the corners to show me where to dig my posts. After I dug the four holes 30″ deep, I stuck the 4×4’s in the ground and used clamps to hold the box to the posts. Then using a level, I leveled the box on all four sides, held it in place with clamps, then concreted the posts in place letting them dry over night.

 photo 20151011_150413.jpg

In the morning, I bolted the box in place with 3/8″ galvanized lag screws using four screws on each post. I then marked where my stringers would be and dug holes for two more posts in the middle of the shed so that the floor won’t sag.

 photo 20151019_092930.jpg

Attaching all the stringers and covering the base of the shed with 3″ deep of gravel stone with landscaping fabric underneath, the shed has a nice base. Now I need to go back to the home center to pick up more lumber.

 photo 20150830_143104.jpg

This is a drawing of the shed I designed. We already bought three old windows for the shed last year, so I incorporated them into the design. We’ll see how close the final shed will look to this drawing.

Advertisements

4 Replies to “And so it Begins- The Shed Part 1”

  1. Setting posts in concrete is quick and strong, but it can contribute to rot in the post bottom. Deck blocks allow better drainage, will settle if the building is heavily loaded (lumber, for instance…). Neither solution distributes building loads like a spread footing (decks assume relatively light loads). We have a backyard structure set on deck blocks that settled a couple of inches over several years time. I was able to lift and level, but it will have a proper footing eventually.

    1. The shed may sag a little, but I’m not too overly concerned as it’s just a shed. I built a massive deck several years ago and it sagged a couple of inches over the years. Even though there’s no frame structure on the deck, it did have 20″ of snow on it. My wife and I have been looking at sheds for the past few years and the one model she fell in love with was The Craftsman from Weaver Barns. They’re high end sheds that look like the shed I designed and they too use frame decking foundations for sloped yards. Hopefully, it’ll be fine.

  2. I’m going to be watching this very closely! Tearing down the old shed we have so I can move all my tools out to a rebuilt shed is a on-going dream of mine. Get’s me out of our horrible basement and I can stop cross contaminating the house with wood shavings!

    The drawing looks incredible. How are you planning to orient the windows for light?

    1. The windows will be just for general lighting. All that will be stored in it are garden tools, a lawnmower, and my blacksmithing tools. The design of the shed is just a design and not a working plan. We’ll see how the actual shed will look like.

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out / Change )

Twitter picture

You are commenting using your Twitter account. Log Out / Change )

Facebook photo

You are commenting using your Facebook account. Log Out / Change )

Google+ photo

You are commenting using your Google+ account. Log Out / Change )

Connecting to %s